Product ID:EXTREME PRESSURE LUBE #3
MSDS Date:11/01/1985
FSC:9150
NIIN:01-234-5110
MSDS Number: BGRCG

EVANS ENGINEERED PRODUCTS CO

6581 MILL ST
GAGETOWN, MI 48735
US

Emergency Phone: 517-665-9913

Info Phone: 517-665-9913

Cage: 0BEZ8

EVANS ENGINEERED PRODUCTS CO

GAGETOWN, MI 48735 US

Telephone: 517-665-9913

Cage: 0BEZ8

PETROLEUM HYDROCARBON (TLV AS OIL MIST 5MG/CUM)

Fraction By Weight: 59.0%

ACGIH TLV: 5MG/CUM(OILMIST

PETROLEUM WAX (BLEND)

Fraction By Weight: 14.3%

ACGIH TLV: 2MG/CUM (MFR)

ADDITIVES

Fraction By Weight: 26.7%

ACGIH TLV: NOT SPECIFIED

LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:NO Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY BE MILDLY IRRITATING.
SKIN:RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF
OIL INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:NOT EXPECTED
TO BE A RELEVANT ROUTE OF EXPO SURE; HIGH TEMPERATURE VAPORS
IRRITATE RESPIRATORY TRACT. INGESTION:LOW LEVEL OF TOXICITY.
CHRONIC: SKIN DISORDERS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS LISTED BY THE
MANUFACTURER IN THIS PRODUCT IS LISTED BY IARC, NTP, OR OSHA AS A
CARCINOGEN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. CONTACT WITH EYE MAY CAUSE BURNING, IRRITATION AND MILD
CONJUNCTIVITIS. INGESTION MAY CAUSE LOCAL IRRITATION OF THE MUCOUS
MEMBRANES-MOUTH,ESOPHAGUS ,STOMACH. LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING
INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH S OAP & WATER/WATERLESS CLEANER. REMOVE CONTAMINATED
CLOTHING. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGESTION:
DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS REQUIRED. GET
MEDICAL ADVICE.

Flash Point Method:COC
Flash Point:445F,229C
Lower Limits:0.9
Upper Limits:7.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS INCLUDING DENSE
SMOKE, ALDEHYDES, PHOSPHINE, AND OXIDES OF PHOSPHORUS,NITROGEN.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS. RESPIRATORY
PROTECTION NOT ORDINARILY R EQUIRED.
Ventilation:LOCAL IF NEEDED TO CAPTURE VAPOR,MISTS,SPRAY OR FUMES.
PROVIDE > 60 FT/MIN HOOD FACE VELOCITY FOR CONFINED SPACES.
Protective Gloves:NEOPRENE RUBBER AS REQUIRED.
Eye Protection:SAFETY GLASSES RECOMMENDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING. AVOID EXPOSURE TO VAPOR.

HCC:V6
Boiling Pt:B.P. Text:246F,119C
Melt/Freeze Pt:M.P/F.P Text:130F,54C
Vapor Pres:0.3 MM
Vapor Density:>20 AIR=1
Spec Gravity:0.9510
Evaporation Rate & Reference:NON-VOLATILE AT ROOM TEMP
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREASE-LIKE SEMI-SOLID, DARK COLOR, PLEASANT ODOR.
Percent Volatiles by Volume:LOW

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES AND GASES (CO) WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES COMBUSTION.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.